Welcome to our peer-to-peer forums, where owners help owners. Need help now? Visit eSupport here.

English Community

ThinkPad NotebooksThinkPad; T61 and prior T series plus Other Legacy ThinkPads
All Forum Topics

8 Posts


Durham, NC

32 Signins

113 Page Views

  • Posts: 8
  • Registered: ‎09-08-2011
  • Location: Durham, NC
  • Views: 113
  • Message 1 of 3

Check CPU Temperatures / Replace Fan / Speed Up System

2011-10-17, 3:11 AM

I have a ThinkPad T61 going on five years old.  Over the last several months it seemed like it might be overheating.  Several times it shut down during heavy activity and/or when the afternoon sun hit the unit in its docking station.  I figured this was due to the move to the more graphics-intensive Windows 7 OS from the original Windows XP.  I did make sure to vacuum out the passages for cooling air.


I recently downloaded a free (!) utility called Real Temp from www.techpowerup.com/realtemp.  This showed both cores running at a temperature in the high 80's/low 90's (degrees Centigrade).


The cooling fan then intermittently began making sounds that indicated a failing bearing.  I have onsite service so I had Lenovo/IBM come out and replace the fan.  (The fan stopped making noise as soon as I placed the service call, of course.)


I then re-ran Real Temp.  The temperatures in both cores were now in the high 40's/low 50's (degrees Centigrade)!!!


The fan had apparently been gradually failing for quite some time, with a reduced flow of cooling air, but the problem only became readily apparent when the bearings started making noise.  The air passages were clear, so the fan had to have been running more slowly that it should have been.


In the time-honored IT tradition of reading the directions only after solving the problem, I looked at some of the (excellent) documentation on the TechPowerUp site for Real Temp.  I learned that as Intel processors approach their upper temperature limit that they slow down, trying to reduce the amount of heat being generated.  Now that my CPU is running at a more normal temperature I can definitely say that my system is running faster.  The fan problem apparently developed gradually over time so I hadn't noticed the slow-down.


If you have a ThinkPad (or any other system with an Intel CPU and an engineered cooling system) that is several years old I would recommend downloading Real Temp and checking your CPU temperature(s).  If they are higher than expected then check the air passages for blockage and, if necessary, replace the cooling fan.  Even if the fan isn't making any noises indicating failure, my experience would indicate that a fan can gradually fail without symptoms and, as a result, slow down system processing speed.


(If you want to replace the fan in your T61 yourself, there is an illustrated step-by-step guide at http://www.insidemylaptop.com/replace-cooling-fan-lenovo-thinkpad-t61-laptop).




2598 Posts



5614 Signins

73478 Page Views

  • Posts: 2598
  • Registered: ‎03-19-2009
  • Location: Germany
  • Views: 73478
  • Message 2 of 3

Betreff: Check CPU Temperatures / Replace Fan / Speed Up System

2011-10-17, 6:11 AM

Nice posting :)


Additional you can do the steps described below before you buy a new fan.:


In most cases dust is blocking the ribs inside the heat sink.

Very often it will help do do the following steps:

  • Turn off computer
  • remove battery and power-supply
  • remove keyboard (see Hardware Maintenance Manual) - if your notebook is in warranty have a look into the parts list, whether the keyboard is a CRU!!!
  • block the fan propeller with a match or toothpick (do not press onto the propeller hub - you may damage the bearing) - if you do not block the propeller, the fan will work as a dynamo and may damage the board!!
  • blow with compressed air spray from outside through the ribs into the heatsink
  • check the space between the propeller and remove fluffs with a pinzette, if there are any
  • clean carefully the upper side with a vacuum cleaner on lowest power from the blown dust while blocking the fan propeller
  • attach, keyboard, battery and  test the temperature again

After cleaning the heat sink the temperature will be very lower than before.



You will do this on your own risk! I do not incur liability for damages.

My home-forum: http://www.thinkpad-forum.de
Wiki: Deutsches ThinkPad-Wiki English ThinkWiki
My ThinkPad-Collection
Coffee must be like women's eyes: deep black & shiny. ThinkPads have to be like men's feet: deep black & matte!

1991 Posts



4725 Signins

59404 Page Views

  • Posts: 1991
  • Registered: ‎05-17-2008
  • Location: USA
  • Views: 59404
  • Message 3 of 3

Betreff: Check CPU Temperatures / Replace Fan / Speed Up System

2011-10-17, 6:18 AM
you can also find an how to replace the fan in the community knowledge base here http://forums.lenovo.com/t5/T61-and-prior-T-series-ThinkPad/T60-T61-Fan-Cleaning-Replacement/ta-p/247953

Thinkpad R61 7733-1GU
Thinkpad X61T 7762-54U
Thinkpad X60T 6363-4GU

Did a member help you today? Thank them with a Kudo!

If a post answers your question, please mark it as an "Accepted Solution"!

Forum Home

Community Guidelines

Please review our Guidelines before posting.

Learn More

Check out current deals!

Go Shop





No, I don’t want to share ideas Yes, I agree to these terms